Product ID:SAND OBLITERATING PAINT, V-1259
MSDS Date:11/22/1989
FSC:8010
NIIN:00-226-3906
MSDS Number: BJKMB

AKRON PAINT AND VARNISH, INC.

1390 FIRESTONE PARKWAY
AKRON, OH 44301-1624
US

Emergency Phone: 216-773-8911

Info Phone: 216-773-8911

Cage: 70228

AKRON PAINT AND VARNISH INC

AKRON, OH 44301-1624 US

Telephone: 216-773-8911

Cage: 70228

ETHYLENE GLYCOL (SARA III)

CAS: 107-21-1

RTECS: KW2975000

Fraction By Weight: 1-5%

OSHA PEL C 50 PPM

ACGIH TLV: C 50 PPM,VAPOR; 9192

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

GLYCOL ETHER DE (VAPOR PRESSURE .1 MMHG)

CAS: 111-90-0

RTECS: KK8750000

Fraction By Weight: 1-5%

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:SKIN:PROLONGED/REPEATED CONTACT CAN
CAUSE MODERATE DEFATTING & DERMATITIS. BREATHING:EXCESSIVE
INHALATION OF VAPORS &/OR MISTS CAN CAUSE UNCONSCIOUSNESS & EVEN
ASPHYXIATION. SWALLOWING: CAN CAUSE GAST ROINTESTIONAL IRRITATION.
ASPIRATION OFMATERIAL INTO THE LUNGS CAN CAUSE CHEMICAL PNEUMONITIS
WHICH CAN BE FATAL.
Explanation of Carcinogenicity:THIS PRODUCT MAY CONTAIN TOXIC CHEMICALS
SUBJECT TO REPORTING REQUIREMENTS OF SECTION 313.
Effects of Overexposure:EYES:REDDNESS, IRRIT, SWELLING & BLURRED
VISION. SKIN:MOD IRRIT & DEFATTING. BREATHING: RESPIRATORY IRRIT,
DIZZ, WEAKNESS, FATIGUE, NAUSEA, HEADACHE, UNCONSCIOUSNESS & EVEN
ASPHYXIATION. SWALLOWING: G ASTROINTESTIONAL IRRIT, NAUSEA,
VOMITING & DIARRHEA; ASPIRATION INTO LUNGS CAN CAUSE CHEM
PNEUMONITIS, POSSIBLY FATAL.

First Aid:EYES:FLUSH W/LG AMT OF H2O FOR 15 MINS LIFTING LIDS, GET
PROMPT MED ATTN. SKIN:WASH THORO W/SOAP & H2O, REMOVE CONTAM
CLOTHES PROMPTLY;WASH BEFORE REUSE. CONSULT PHYSICIAN IF IRRIT
PERSIST. SWALLOW:DO N'T INDUCE VOMIT, CAN CAUSE CHEM PNEUMONITIS,
CAN BE FATAL. DRINK H2O TO DILUTE. INHALED:MOVE TO FRESH AIR. IF
BREATH DIFF, ADMIN OXYGEN. IF BREATH STOPPED, GIVE CPR. KEEP
WARM/QUIET & GET MED ATTN.

Flash Point Method:TCC
Flash Point:196 F/91 C
Lower Limits:1.2
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER FOG. USE
WATER FOR COOLING MATERIAL STORED IN VICINITY OF FIRE.
Fire Fighting Procedures:USE SCBA W/FULL FACEPIECE OPERATED IN
PRESSURE-DEMAND OR OTHER POSITIVE PRESSURE MODE. WEAR PROTECTIVE
CLOTHING.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR, MAY TRAVEL
ALONG GROUND TO IGNITION SOURCES DISTANT FROM MATERIAL HANDLING
POINT. NEVER USE CUTTING TORCH ON EMPTY CONTAINER *

Spill Release Procedures:SM:ABSORB LIQ W/RAGS/FLOOR
ABSORB/VERMICLITE/OTHER & TRANSFER TO HOOD. LG:ELIM ALL IGNITE
SOURCES, DIKE AREA OF SPILL TO PREVENT SPREAD, VENT AREA IF
INDOORS, PUMP LIQ INTO SALVAGE TANK, REMAINING LIQ TAKE UP W/SAND,
ETC. & SHOVEL INTO CONTAINERS **
Neutralizing Agent:N/K. ** PREVENT RUN-OFF TO SEWERS & BODIES OF WATER.
NOTIFY PROPER AUTHORITIES.

Handling and Storage Precautions:DO NOT DROP CONTAINERS. AVOID HEAT,
SPARKS AND OPEN FLAME. STORE LARGE QUANTITIES ONLY IN BUILDINGS
DESIGNED TO COMPLY WITH OSHA 1910.106.
Other Precautions:*NEVER USE CUTTING TORCH ON EMPTY CONTAINERS!
RESIDUAL SOLVENT VAPOR IN EMPTY CONTAINER MAY EXPLODE. APPLY TO HOT
SURFACES W/SPECIAL PRECAUTION. OVEREXPOS TO DECOMP PRODUCTS MAY BE
HEALTH HAZARD. SYMP MAY NOT BE IMMED APPARENT. OBTAIN MED.

Respiratory Protection:IN OUTDOOR OR OPEN AREAS WITH UNRESTRICTED
VENTILATION, REMOVE CHEMICAL/MECHANICAL FILTERS DESIGNED TO REMOVE
A COMBINATION OF PARTICULATES AND VAPOR. IN CONFINED AREAS,
APPROVED AIR LINE TYPE RESPIRA TORS OR HOODS.
Ventilation:SUFF VENT IN VOL/PATTERN TO KEEP AIR CONTAM CONCENTRATE
BELOW PERMISSIBLE EXPOSURE/EXPLOSIVE LIMIT.REMOVE DECOMP PRODUCT
Protective Gloves:RESISTANT GLOVES SUCH AS: NITRILE RUBBER
Eye Protection:CHEM SPLASH GOGGLES, OSHA PERMITS OTHER
Other Protective Equipment:NORMAL PROTECTIVE CLOTHING. WASH
CONTAMINATED CLOTHING BEFORE REUSE. (CONSULT YOUR SAFETY EQUIPMENT
SUPPLIER)
Supplemental Safety and Health
HOT ORGANIC CHEMICAL VAPOR OR MISTS ARE SUSCEPTIBLE TO SUDDEN
SPONTANEOUS COMBUSTION WHEN MIXED WITH AIR. IGNITION MAY OCCUR AT
TEMPERATURES BELOW THOSE PUBLISHED IN THE LITERATURE AS
"AUTOIGNITION" O R "IGNITION" TEMPERATURES.

Boiling Pt:B.P. Text:212 TO 401F
Vapor Density:> THAN AIR
Spec Gravity:1.30
Evaporation Rate & Reference:0.0 X N-BUTYL ACETATE
Appearance and Odor:SAND PAINT
Percent Volatiles by Volume:63.4

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZERS (E.G. NITRIC ACID).
Stability Condition to Avoid:KEEP AWAY FROM HEAT AND OPEN FLAME.
Hazardous Decomposition Products:MAY FORM CARBON MONOXIDE AND DIOXIDE,
VARIOUS HYDROCARBONS, ETC.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.